Product ID:513X377 URETHANE COMPATIBLE PRIMER
MSDS Date:08/28/1989
FSC:8010
NIIN:00F041283
Kit Part:Y
MSDS Number: BXNKK

DESOTO INC

1700 S MOUNT PROSPECT
DES PLAINES, IL 60017-5000
US

Emergency Phone: 312-391-9000

Info Phone: 312-391-9000

Preparer: SUZANNE M RODGERS

Cage: 62758

DESOTO INC

DES PLAINES, IL 60018-1804 US

Telephone: 708-391-9000

Cage: 62758

BUTYL ACETATE (N-BUTYL ACETATE) *95-2*

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 30%

OSHA PEL 710 MG/CUM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (IARC CARC- GROUP 3) *95-2*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5-10%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NON-HAZARDOUS ADDITIVES, RESINS & PIGMENTS

Fraction By Weight: 25%

CYCLOHEXANONE, KETOHEXAMETHYLENE

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: 10%

OSHA PEL 50 PPM

ACGIH TLV: 100 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

STRONTIUM CHROMATE (SUSPECTED HUMAN CARCINOGEN BY ACGIH,

CAS: 7789-06-2

RTECS: GB3240000

Fraction By Weight: 15%

OSHA PEL 100 UG/CUM

ACGIH TLV: 0.001 MG/CUM IC

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

SILICON DIOXIDE, CRYSTALLINE QUARTZ, SAND (ANIMAL CARC,

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 15%

OSHA PEL 0.1 MG/CUM RESP DUST

ACGIH TLV: 0.1 MG/CUM RESP DUST

553 GRAMS/LITER

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL/RESPIRATORY
IRRITANT, CNS DEPRESSION, ASPHYXIANT MAY RESULT FROM BREATHING
OXYGEN DEFICIENT AIR. SKIN: IRRITANT, DERMATITIS. EYES: IRRITANT.
INGESTION: GI IRRITANT. ASPIRATION INTO T HE LUNGS CAN CAUSE
CHEMICAL PNEUMONITIS/FATAL. OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS, ASPHYXIATION, DEFATTING, NAUSEA,
VOMITING, DIARRHEA. OVEREXPOSURE TO SOLVENTS: CONCENTRATION
DIFFICULTIES, DIMINISHED MANU AL DEXTERITY, MEMORY LOSS
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, LUNG & EYE
CONDITIONS.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. KEEP WARM & QUIET. SKIN: WASH W/SOAP & WATER. DON'T USE
SOLVENTS. EYES: FLUSH W/WATER FOR 15 MINS. INGESTION: ASPIRATION
HAZARD. OBTAIN M EDICAL ATTENTION IN ALL CASES.

Flash Point:45F
Lower Limits:1.1
Extinguishing Media:CO2, DRY CHEMICAL/FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. COOL FIRE
EXPOSED CONTAINERS W/WATER. FOG NOZZLES ARE PREFERRED. WEAR
NIOSH/MSHA APPROVED SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY ACCUMULATE IN INADEQUATELY
VENTILATED/CONFINED AREAS/FORM EXPLOSIVE MIXTURES W/AIR. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.(SUPP)

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. WEAR PROTECTIVE
EQUIPMENT. USE NON-SPARKING TOOLS. SMALL: DIKE & ABSORB W/INERT
MATERIAL. DON'T CONTAMINATE GROUND/SURFACE WATER.

Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED & AWAY
FROM IGNITION SOURCES. DON'T STORE >120F. GROUNDING & BONDING
PROCEDURES SHOULD BE USED WHEN TRANFERRING MATERIAL
Other Precautions:STORE FLAMMABLE LIQUIDS IAW/APPLICABLE NFPA CODES &
GOVERNMENTAL REGULATIONS. AVOID FREE FALL OF LIQUID. DON'T SMOKE
WHERE MATERIAL IS USED/STORED. DON'T TAKE INTERNALLY. DON'T
DELIBERATELY CONCENTRAT E/INHALE VAPORS. AVOID SKIN CONTACT.

Respiratory Protection:WHERE TLVS MAY BE EXCEEDED/IF SPRAY MIST IS
PRESENT, USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION. IN
CONFINED AREAS, USE NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATORS.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST IN VOLUME & PATTERN TO KEEP
LEVELS BELOW RECOMMENDED/REGULATED LIMITS. KEEP BELOW 25% LEL
Protective Gloves:CHEMICALLY RESISTANT
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS/GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, EYE BATH
& WASHING FACILITIES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
FIRE HAZ CONT'D: VAPORS MAY TRAVEL LONG DISTANCES; FLASHBACK/FLAME TO
HANDLING SITE MAY OCCUR. VAPORS ARE >AIR & MAY COLLECT IN
LOW/CONFINED AREAS. DON'T ENTER SUCH AREAS W/OUT FOLLOWING
APPROPRIATE P ROCEDURES. PREVENT PROLONGED CONTACT W/CONTAMINATED
CLOTHING.

Boiling Pt:B.P. Text:232-313F
Vapor Density:>1
Spec Gravity:1.22
Evaporation Rate & Reference:SLOWER THAN N-BU ACETATE
Appearance and Odor:LIQUID W/SOLVENT ODOR
Percent Volatiles by Volume:62.6

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, FLAME,
HOT SURFACES & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:WHEN DISPOSING OF MATERIAL, ENSURE THAT IT'S
PACKAGED, STORED, TRANSPORTED & OTHERWISE MANAGED IAW/LOCAL, STATE
& FEDERAL REGULATIONS. EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS.
DON'T CUT, PUNCTURE/WEL D ON/NEAR DRUM. FLAMMABLE LIQUID UN1263.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.